Exhaust Replacement SC 430 2002

[Graham Wilkinson]

Good Evening All,

Thank you so much for those who have assisted me so far as a new member.Water ingress to the footwell was resolved by flushing out in the drain hole in the lower sill O/S and did the trick.

Have yet to use the Honda Shin Etsu grease on all rubber seals,bought 2 tubes and waiting for the Cumbrian weather to improve before I-apply this treatment( to all seals eg doors,boot,roof etc)thanks for this advise.

I asked a Lexus dealer to provide an estimate how much it would cost to replace the entire exhaust system.I needed smelling salts to bring me round!! The estimates was 5400k.I asked an independent garage to check the condition and his view was to replace from the cat/ converter to the silencer was necessary at this stage.Has any member had bespoke  stainless steel replacements made or indeed similar replacements  and if so which company and if you don’t mind me asking the comparative costs.Any experiences on the exhaust front also very welcome.

On other matters I am considering to replace the aux/fan belt,cam belt which is somewhat over due,at the same time would you advise replacing the water pump at the same time? (Milage 69k now) 

My wife and I just love the car it is quite a joy to drive,and yes I did allow her to drive it!! (WELL ONCE)

Many Thanks Graham.

Ps.Bought a half cover from Classic Additions which cost 105 pounds and is very high quality.

[#Sandy#]

I would recommend changing the water pump and auxiliary belt at the same time. It’s a tick in the box for peace of mind.

There are specialists out there, speak to your local garage, they may recommend a reputable firm.

[Graham Wilkinson]

Thank you Sandy,will do.

 

[Russ59]

Graham,

Sorry I don’t know anyone up your way, but I have recently had  mine replaced at my local stainless exhaust place from the 3rd cat back (where the 2 front pipes join) in stainless and I paid £900.

That should give you an idea wether you need part or full system.

I also went for 2 separate rear boxes as opposed to the original 1

 

 

[royoftherovers]

16 minutes ago, Russ59 said:

Graham,

Sorry I don’t know anyone up your way, but I have recently had  mine replaced at my local stainless exhaust place from the 3rd cat back (where the 2 front pipes join) in stainless and I paid £900.

That should give you an idea wether you need part or full system.

I also went for 2 separate rear boxes as opposed to the original 1

 

 

Tony Banks of Leeds will assist you. I`m sure that Ant is familiar with him.https://www.tonybanks.co.uk/

[Lexiguy]

Yes Bob you are right, I had mine replaced from the front cats back at Tony Banks in Leeds specialist exhaust fabricators and the workmanship is superb.

It was about £900 and I chose which tailpipes, single or twin each side, also which chrome finishers I wanted from a selection they have.

Apparently they have done a dozen or so SC430's so that gave me the confidence they would know what they were doing!

They did mine in about 5 hours while I went into Leeds City centre to pass some time.

It included a new middle cat and is guaranteed for as long as you have the vehicle. Also if it is a standard looking exhaust there would be no awkward questions in the event of making an insurance claim.

If gentle on the throttle it bubbles like a V8 should but if you put your foot hard down it really sounds fabulous. At a £1 a smile I must have had over 900!

 

 

[Glyn Jennings]

Hi Anthony, out of interest how much do you hear your exhaust with the roof and windows up? With my straight through muffler delete I do hear the exhaust every time I touch the throttle. Whereas when I am not touching the accelerator I don’t here the exhaust at all.

[Lexiguy]

Hi Glyn

Mine is the same not heard with top up and windows closed unless I give it some gas.

They got it just right for me!

[Graham Wilkinson]

On 11/19/2022 at 10:04 AM, Russ59 said:

Graham,

Sorry I don’t know anyone up your way, but I have recently had  mine replaced at my local stainless exhaust place from the 3rd cat back (where the 2 front pipes join) in stainless and I paid £900.

That should give you an idea wether you need part or full system.

I also went for 2 separate rear boxes as opposed to the original 1

 

 

Russ thanks this very reassuring many thanks!! G.

[Graham Wilkinson]

On 11/19/2022 at 10:22 AM, royoftherovers said:

Tony Banks of Leeds will assist you. I`m sure that Ant is familiar with him.https://www.tonybanks.co.uk/

John,Many thanks really helpful will do.G.

[Graham Wilkinson]

On 11/21/2022 at 2:24 PM, Lexiguy said:

Yes Bob you are right, I had mine replaced from the front cats back at Tony Banks in Leeds specialist exhaust fabricators and the workmanship is superb.

It was about £900 and I chose which tailpipes, single or twin each side, also which chrome finishers I wanted from a selection they have.

Apparently they have done a dozen or so SC430's so that gave me the confidence they would know what they were doing!

They did mine in about 5 hours while I went into Leeds City centre to pass some time.

It included a new middle cat and is guaranteed for as long as you have the vehicle. Also if it is a standard looking exhaust there would be no awkward questions in the event of making an insurance claim.

If gentle on the throttle it bubbles like a V8 should but if you put your foot hard down it really sounds fabulous. At a £1 a smile I must have had over 900!

 

 

That is great,thanks! Looks like we have a day out of retail therapy in Leda coming up soon!! G.

[Graham Wilkinson]

On 11/21/2022 at 8:11 PM, Lexiguy said:

Hi Glyn

Mine is the same not heard with top up and windows closed unless I give it some gas.

They got it just right for me!

Thanks Antony,Appreciated.G.

[DAN@ADRIAN FLUX]

Hi.

Hopefully you wouldn't but if you did have any issues with insurance for the fitment of a non standard exhaust system then please feel free to drop me a line.

Regards,

Dan.

[Glyn Jennings]

49 minutes ago, DAN@ADRIAN FLUX said:

Hi.

Hopefully you wouldn't but if you did have any issues with insurance for the fitment of a non standard exhaust system then please feel free to drop me a line.

Regards,

Dan.

I told my insurance company I had aftermarket wheels and exhaust mod. No extra charge but there always seems an admin charge.

 

[Lexiguy]

Isn't it always the case Glyn!

[Sonu]

Mine was done by Richs fabrication shop. As far as custom exhaust go it is OK, no HKS, but is mandrel bent with lifetime warranty. 

https://www.facebook.com/watch/?v=894317461169314

[Graham Wilkinson]

Thanks Sonu appreciated,Graham.

[Localhero]

On 21/11/2022 at 2:24 PM, Lexiguy said:

Yes Bob you are right, I had mine replaced from the front cats back at Tony Banks in Leeds specialist exhaust fabricators and the workmanship is superb.

It was about £900 and I chose which tailpipes, single or twin each side, also which chrome finishers I wanted from a selection they have.

Apparently they have done a dozen or so SC430's so that gave me the confidence they would know what they were doing!

They did mine in about 5 hours while I went into Leeds City centre to pass some time.

It included a new middle cat and is guaranteed for as long as you have the vehicle. Also if it is a standard looking exhaust there would be no awkward questions in the event of making an insurance claim.

If gentle on the throttle it bubbles like a V8 should but if you put your foot hard down it really sounds fabulous. At a £1 a smile I must have had over 900!

 

 

I fully endorse all that Ant says above had mine done there 2yrs ago and it is excellent, the owner told me that one sc owner drove from Paris to get his done!!